• Energy Research

The effect of fluid dynamic conditions on enzymatic hydrolysis of acid pretreated corn stover (PCS) has been assessed. Runs were performed in stirred tanks at several stirrer speed values, under typical conditions of temperature (50°C), pH (4.8) and solid charge (20% w/w). A complex mixture of cellulases, xylanases and mannanases was employed for PCS saccharification. At low stirring speeds (<150rpm), estimated mass transfer coefficients and rates, when compared to chemical hydrolysis rates, lead to results that clearly show low mass transfer rates, being this phenomenon the controlling step of the overall process rate. However, for stirrer speed from 300rpm upwards, the overall process rate is controlled by hydrolysis reactions. The ratio between mass transfer and overall chemical reaction rates changes with time depending on the conditions of each run.

Enzymatic hydrolysis of three pre-treated lignocellulosic biomasses -LCB- (wheat straw-WS-, corn stover-CSV- and cardoon stems -CS-) is studied. These biomasses were pre-treated by two methods: diluted sulfuric acid and acid ethanol-water extraction at six severity levels (H values). Pretreated solid fractions were hydrolyzed with commercial enzyme cocktails at standard conditions. A first-order kinetic fractal model was fitted to the experimental results. This model accurately describes the hydrolysis of all biomasses at all pre-treatment conditions studied. The results show that the formal first-order kinetic constant k depends on the biomass nature. The hydrolysis rate increases as the pre-treatment severity does, while the fractal exponent value h decreases. With these pre-treatments, and in terms of k and h, WS is highly reactive and, at medium H with EW pretreatment, highly accessible; CSV has a low reactivity and high accessibility and CS has the lowest reactivity and an increasing accessibility as severity rises.

The inhibition of the enzymatic saccharification of acid pretreated corn stover (PCS) biomass due to several compounds either present in PCS or produced during saccharification has been studied. The prospective inhibitors tested were glucose (≤110�g�L−1), celobiose (≤24�g�L−1), xylose (≤50�g�L−1), arabinose (≤1.5�g�L−1), furfural (≤2�g�L−1), hydroxymethylfurfural (≤1�g�L−1), acetic acid (≤4�g�L−1), and lignin (≤50�g�L−1). Each of these compounds was added at three different concentrations, being the concentration intervals different according to standard maximum concentrations of such compounds in the reaction medium, previously measured and described in literature. In addition, these experiments were employed to evaluate the standard error present during the evaluation of the results obtained in the inhibition reactions. Those results show that significant inhibition was only detected for lignin (more than 25�g�L−1) and it was also appreciable for glucose at high concentrations (above 75�g�L−1), although it was not remarkable at medium concentrations (40�g�L−1). On the other hand, neither of the remaining compounds tested presented any significant inhibitory effect at the usual process concentration range. � 2017 Elsevier Ltd

The stabilization effects on a novel commercial β-glucosidase preparation from Aspergillus fumigatus during saccharification of ethanol-water pretreated wheat straw were analysed in comparison to this enzyme stability during cellobiose hydrolysis. For this purpose, the kinetics of β-glucosidase residual activity during cellobiose hydrolysis from 40 till 70 °C were studied, resulting in the fitting of a first-order partial deactivation model. Furthermore, a subsequent fitting of a kinetic model including this first-order deactivation equation and a Michaelis-Menten equation with double competitive inhibition by glucose and uncompetitive inhibition by cellobiose to released glucose was successful. Finally, global enzyme deactivation and prospective deactivation of enzyme remaining in the liquid phase were evaluated during wheat straw hydrolysis at 50 °C as a relevant saccharification process. Results suggest that the presence of a solid substrate dramatically reduces the global deactivation rate of the enzyme and, in addition, there is no loss the stability of the enzyme in the liquid phase along the saccharification process, even for 72 h.

The fractionation of wheat straw by ethanol-water (EW) pre-treatment was studied regarding its main operating conditions: time, temperature, L/S ratio and ethanol percentage were optimized by using an orthogonal experimental design (Taguchi). Afterwards, diluted sulfuric acid (DSA) hydrolysis and EW treatments have been compared in terms of energy consumption and yield of a cellulosic solid residue able to be enzymatically hydrolyzed to glucose. Experimental results show that temperature is the only variable of EW with a significant effect on the quality of the pretreated solids. EW pre-treatment of wheat straw is more effective than DSA hydrolysis due to its higher capacity of delignification. Moreover, a high glucose yield (80%) can be obtained by enzymatic hydrolysis of a solid pretreated with a moderate energy input EW (160 °C, 45 min) while wheat straw needs of a higher energy input during DSA to produce a similar yield of glucose after saccharification.